Open Access Open Access  Restricted Access Subscription or Fee Access

Modeling and Analysis of the Impact of Natural Gas Composition Variations on Combustion in a Dual Fuel Compression Ignition Engine

Matthew Hulbert, Wenbo Sui, Mateos Kassa, Carrie Michele Hall

Abstract


The desire to meet rising energy demands while simultaneously adhering to stringent climate policies has propelled advanced combustion technologies and alternative fuels. Natural gas (NG) is an attractive, domestically-available alternative that has been shown to achieve high efficiencies when used on dual fuel engines. However, the composition of NG can vary significantly depending on the source and these variations may detrimentally impact engine operation. To study these effects, a dual fuel engine simulation model was developed and calibrated against experimental data obtained from a heavy-duty 6-cylinder dual fuel compression ignition engine. Different NG compositions were studied on this simulation model to analyze the impact that composition plays on the combustion process in a dual fuel engine architecture. The results show that composition can play a significant role in the combustion efficiency, peak pressure, and combustion phasing. These impacts were studied in a constant equivalence ratio case in which differences in stoichiometric air-fuel ratios were taken into account. The results reveal that if variations in stoichiometric air-fuel ratio are accounted for, blends with high methane contents and low nitrogen behave similarly.


Keywords


dual fuel engine; natural gas combustion; fuel variation; combustion phasing; combustion efficiency

Full Text:

PDF

References


A. Sieminski, ""International Energy Outlook 2016," 30 April 2017. [Online]. Available: https://www.eia.gov/pressroom/presentations/sieminski_05112016.pdf.

ExxonMobil, "Natural Gas," [Online]. Available: http://corporate.exxonmobil.com/en/energy/energy-outlook/natural-gas/. [Accessed June 29 2017].

U. Kramer, T. Lorenz, C. Hofmann, H. Ruhland, R. Klein and C. Weber, "Methane Number Effect on the Efficiency of a Downsized, Dedicated, High Performance Compressed Natural Gas (CNG) Direct Injection Engine," SAE Technical Paper 2017-01-0776, 2017.

Union Gas, "About Natural Gas - Union Gas," [Online]. Available: https://www.uniongas.com/about-us/about-natural-gas.. [Accessed 29 June 2017].

ExxonMobil., "Transportation," [Online]. Available: http://corporate.exxonmobil.com/en/energy/energy-outlook/transportation/. [Accessed 29 June 2017].

L. Wei and P. Geng, "A Review on Natural Gas/diesel Dual Fuel Combustion, Emissions and Performance," Fuel Processing Technology, vol. 142, pp. 264-278, 2016.

V. Pirouzpanah and R. K. Sarai, "Reduction of Emissions in an Automotive Direct Injection Diesel Engine Dual-fueled with Natural Gas by Using Variable Exhaust Gas Recirculation," Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, vol. 217, no. 8, pp. 719-725, 2013.

C. S. Weaver and S. H. Turner, "Dual Fuel Natural Gas/Diesel Engines: Technology, Performance, and Emissions," SAE Technical Paper 940548, 1994.

S. Akansu, "Internal Combustion Engines Fueled by Natural Gas/hydrogen Mixtures," International Journal of Hydrogen Energy, vol. 29, no. 14, pp. 1527-1539, 2004.

T. Korakianitis, A. Namasivayam and R. Crookes, "Natural-gas Fueled Spark-ignition (SI) and Compression-ignition (CI) Engine Performance and Emissions," Progress in Energy and Combustion Science, vol. 37, no. 1, pp. 89-112, 2011.

R. M. Hanson, S. L. Kokjohn, D. A. Splitter and R. D. Reitz, "An Experimental Investigation of Fuel Reactivity Controlled PCCI Combustion in a Heavy-Duty Engine," SAE International Journal of Engines, vol. 3, no. 1, pp. 700-716, 2010.

W. Fang, B. Huang, D. B. Kittelson and W. F. Northrop, "Dual-Fuel Diesel Engine Combustion with Hydrogen, Gasoline, and Ethanol as Fumigants: Effect of Diesel Injection Timing," Journal of Engineering for Gas Turbines and Power, vol. 136, no. 8, 2014.

S. L. Kokjohn, R. M. Hanson, D. A. Splitter and R. D. Reitz, "Experiments and Modeling of Dual-Fuel HCCI and PCCI Combustion Using In-Cylinder Fuel Blending," SAE International Journal of Engines, vol. 2, no. 2, pp. 24-39, 2009.

V. Manente, B. Johansson and P. Tunestal, "Partially Premixed Combustion at High Load Using Gasoline and Ethanol, a Comparison with Diesel," SAE Technical Paper 2009-01-0944, 2009.

S. J. Curran, J. P. Szybist and R. M. Wagner, "Reactivity Controlled Compression Ignition Performance with Renewable Fuels," in Proceedings of the ASME 2012 Internal Combustion Engine Division Fall Technical Conference, 2012.

S. Kokjohn, R. Hanson, D. Splitter and R. Reitz, "Fuel reactivity controlled compression ignition (RCCI): a pathway to controlled high-efficiency clean combustion," International Journal of Engine Research, vol. 12, no. 3, pp. 209-226, 2011.

D. Splitter, M. Wissink, D. Delvescovo and R. D. Reitz, "RCCI Engine Operation Towards 60% Thermal Efficiency," SAE Technical Paper 2013-01-0279, 2013.

M. Kassa, C. Hall, A. Ickes and T. Wallner, "Modeling and Control of Fuel Distribution in a Dual Fuel Internal Combustion Engine Leveraging Late Intake Valve Closings," International Journal of Engine Research, vol. 18, no. 8, pp. 797-809, 2016.

J. Bittle, J. Zheng, X. Xue, H. Song and T. Jacobs, "Cylinder-to-cylinder Variation Sources in Diesel Low Temperature Combustion and the Influence They Have on Emissions," International Journal of Engine Research, vol. 15, no. 1, pp. 112-122, 2014.

M. Y. Selim, "Pressure-time Characteristics in Diesel Engine Fueled with Natural Gas," Renewable Energy , vol. 22, no. 4, pp. 473-489, 2001.

R. Papagiannakis and D. Hountalas, "Experimental Investigation concerning the Effect of Natural Gas Percentage on Performance and Emissions of a DI Dual Fuel Diesel Engine," Applied Thermal Engineering, vol. 23, no. 3, pp. 353-365, 2003.

M. A. H. Abdelaal, "Combustion and Emission Characteristics of a Natural Gas-fueled Diesel Engine with EGR," Energy Conversion and Management, vol. 64, pp. 301-312, 2012.

L. Shenghua, W. Ziyan and R. Jiang, "Development of Compressed Natural Gas/diesel Dual-fuel Turbocharged Compression Ignition Engine," Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, vol. 217, no. 9, pp. 839-845, 2003.

S. Imran, D. Emberson, B. Ihracska, D. Wen, R. Crookes and T. Korakianitis, "Effect of Pilot Fuel Quantity and Type on Performance and Emissions of Natural Gas and Hydrogen Based Combustion in a Compression Ignition Engine," International Journal of Hydrogen Energy, vol. 39, no. 10, pp. 5163-5175, 2014.

M. S. Lounici, K. Loubar, L. Tarabet, M. Balistrou, D.-C. Niculescu and M. Tazerout, "Towards Improvement of Natural Gas-diesel Dual Fuel Mode: An Experimental Investigation on Performance and Exhaust Emissions," Energy, vol. 64, pp. 200-211, 2014.

C. Rahmouni, "Determination of the Combustion Properties of Natural Gases by Pseudo-Constituents," Fuel, vol. 82, no. 11, pp. 1399-1409, 2003.

J. Heywood, Internal Combustion Engine Fundamentals, Singapore: McGraw-Hill, 1988.

G. Fodor, "Analysis of Natural Gas by FT-IR; Calibrations & Validations," U.S. Army TARDEC, 1997.

Å. Skrbic, D. Biljana and J. Cvejanov, "Comparative Analysis of Methods for Determination of Calorific Values of Natural Gas Mixtures," Fuel Processing Technology, vol. 28, no. 3, pp. 307-314, 1991.

R. J. Reed, North American Comustion Handbook, Cleveland, OH, 1986.

M. Hulbert, The Impact of Alternative Fuels on Dual Fuel Engine Performance and Emissions, Illinois Institute of Technology: M.S. Thesis, 2017.




DOI: https://doi.org/10.37591/joaea.v5i2.953

Refbacks

  • There are currently no refbacks.